2004 Freightliner BUSINESS CLASS M2 Recalls
NHTSA has 10 recall campaigns on file for the 2004 Freightliner BUSINESS CLASS M2. Every repair below is free at a franchised dealer, by federal law.
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
ON CERTAIN TRUCKS, INCORRECT SPRINGS WERE INSTALLED IN THE EXHAUST PORT OF CERTAIN AIR MANAGEMENT UNIT (AMU) SOLENOID VALVES AND THEY MAY NOT TURN OFF AFTER ACTUATION.
Risk: DEPENDING ON THE FUNCTION AFFECTED, THIS COULD RESULT IN REAR SUSPENSION AIR PRESSURE LOSS, MALFUNCTION OF THE ENGINE BRAKE, PERMANENT ENGAGEMENT OF THE REAR AXLE DIFFERENTIAL LOCK, OR PREVENT ENGAGEMENT OF THE FIFTH WHEEL SLIDE LOCK. IF THE WARNING INDICATORS IN THE DASH ARE NOT HEEDED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE AFFECTED VALVES. THE RECALL BEGAN JUNE 29, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
POWER TRAIN:MANUAL TRANSMISSION
ON CERTAIN TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, THE TAPERED JOINT THAT ATTACHES THE SHIFTER TO THE TRANSMISSION MAY BECOME LOOSE MAKING IT DIFFICULT TO PUT THE TRANSMISSION INTO GEAR.
Risk: IF SHIFT LEVER DETACHMENT OCCURS, THA ABILITY RO ACCELERATE OT MAINTAIN SPEED WILL BE LOST, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-SECURE THE SHIFT LEVER TO THE TRANSMISSION USING THREADLOCK AND RE-TORQUING THE FASTENING BOLT. OWNER NOTIFICATION BEGAN ON MAY 21, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
TIRES
CERTAIN MICHELIN XDE COMMERCIAL TRUCK TIRES, SIZE 10R22.5 LRG AND LRF FOR USE ON FREIGHTLINER SCHOOL AND TRANSIT BUSES. THESE TIRES WERE MANFACTURED BETWEEN MAY 23 AND OCTOBER 24, 2004, CAN EXPERIENCE RAPID AIR LOSS DUE TO AN IRREGULARITY OF THE INNER LINER.
Risk: RAPID AIR LOSS CAN RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH CAN OCCUR.
Remedy: MICHELIN WILL NOTIFY ITS CUSTOMERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN DECEMBER 27, 2004. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MICHELIN AT 888-622-2306.
FUEL SYSTEM, DIESEL
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.
Risk: THIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
POWER TRAIN:AXLE ASSEMBLY
DAIMLER TRUCKS IS RECALLING 28,764 MY 2001 THROUGH 2008 FCCC B2 AND FS65 SCHOOL BUS CHASSIS, FCCC FB65 CONVENTIONAL BUSES, AND STERLING ACTERRA, FREIGHTLINER FLN, AND BUSINESS CLASS M2 HEAVY TRUCKS, BUILT FROM JANUARY 26, 2000, THROUGH MARCH 24, 2008, MANUFACTURED WITH ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 THROUGH 8,000 POUND FRONT AXLES UTILIZING A FOUR PIECE SPINDLE-NUT SET. THESE AXLE ASSEMBLIES MAY HAVE BEEN PRODUCED WITH A THIN SPINDLE NUT WHICH MAY LEAD TO INCORRECT END PLAY, CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.
Risk: CONTINUED OPERATION MAY LEAD TO WHEEL SEPARATION AND POSSIBLY A VEHICLE CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 24,650 SCHOOL AND NON-SCHOOL BUSES, MOTOR HOME CHASSIS, AND TRUCKS MANUFACTURED FROM MARCH 9, 2004 THROUGH AUGUST 18, 2006, EQUIPPED WITH EPA04 CERTIFIED MBE900 ENGINES, MANUFACTURED BY DETROIT DIESEL BETWEEN MARCH 1, 2004, AND JULY 31, 2006. THE HIGH PRESSURE FUEL LINES AND TRANSFER TUBES MAY FATIGUE AND FRACTURE.
Risk: A FRACTURED FUEL LINE MAY LEAK DIESEL FUEL POSSIBLY RESULTING IN A FIRE OR FUEL MAY BE SPILLED ON THE ROAD CAUSING A SLIPPERY SURFACE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DETROIT DIESEL WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED WITH MORE ROBUST LINES AND VIBRATION DAMPERS FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY AUTHORIZED DETROIT DIESEL DISTRIBUTORSHIPS. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT DETROIT DIESEL 1-313-592-3708 OR DTNA TOLL-FREE AT 1-800-547-0712 FOR MORE INFORMATION.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
CERTAIN MY 2004 FREIGHTLINER BUSINESS CLASS M2 AND THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BETWEEN JULY 26 AND OCTOBER 29, 2004, EQUIPPED WITH A CATERPILLAR C-7 ENGINE AND BORG-WARNER KYS 4735 35480 55 ENGINE FAN. THE FAN SHROUD MAY BE DRAWN BACK INTO THE FAN AT HIGH ENGINE SPEEDS WHEN THE FAN CLUTCH ENGAGES. DUE TO REDUCED CLEARANCE, HEAVY CONTACT BETWEEN THE FAN AND THE SHROUD MAY CAUSE THE FAN BLADE TO FRACTURE.
Risk: THE FAN MAY FRACTURE AND PIECES MAY SEPARATE FROM THE FAN BLADE. IN CERTAIN CONDITIONS, THIS MAY PRESENT A HAZARD TO PEOPLE NEAR THE VEHICLE WITH THE HOOD OPEN AND THE ENGINE RUNNING.
Remedy: FREIGHTLINER WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ENGINE FAN WITH A FAN THAT HAS A DIFFERENT MOUNTING OFFSET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON JANUARY 16, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
PARKING BRAKE
CERTAIN 2004 AND 2005 THOMAS BUILT C2 SCHOOL BUSES AND FREIGHTLINER BUSINESS CLASS M2 HEAVY TRUCKS MANUFACTURED BETWEEN JUNE 2004 AND MARCH 2005. THE ANCHOR/PIVOT BOLT SUPPLIED WITH THE PARK BRAKE IS DEFECTIVE AND COULD FATIGUE FRACTURE PREMATURELY, RESULTING IN THE PARK BRAKE FAILING TO APPLY.
Risk: IF THE PARK BRAKE ANCHOR BOLT FATIGUES AND ULTIMATELY FRACTURES, THE PARK BRAKE MAY NOT FUNCTION AND THERE MAY BE NO INDICATION TO THE DRIVER OF THE MALFUNCTION WHEN THE PARK BRAKE IS SET. THIS MAY CAUSE THE VEHICLE TO ROLL AWAY WITHOUT WARNING, WHICH COULD RESULT IN A CRASH.
Remedy: FREIGHTLINER WILL NOTIFY ITS OWNERS AND INSPECT AND REPLACE DEFECTIVE ANCHOR BOLTS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
ON CERTAIN TRUCKS AND FIRE TRUCKS EQUIPPED WITH KYS 4735-43782-02 ENGINE COOLING FANS AND BUILT ON CATERPILLAR 3126, C7, MBE906, MBE926, OR CUMMINS ISC ENGINES, THE STEEL FAN INSERT ON THE COOLING FANS CAN CRACK.
Risk: THIS CAN RESULT IN FAN BREAKAGE, RESULTING IN VEHICLE DAMAGE OR PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ENGINE COOLING FAN FREE OF CHARGE. THE RECALL BEGAN ON JUNE 8, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Risk: THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Does this apply to your BUSINESS CLASS M2?
Campaigns list every affected vehicle at the model level, but individual vehicles may already be repaired or fall outside the affected production range. Check a specific VIN with the Freightliner recall lookup — free — or see other 2004 Freightliner models with recalls. Source: official NHTSA recall database.